CreatorWorship

At first the owner just wanted the decking replaced, but I noticed that the center of the deck was several inches higher than around it. I went to look underneath and discovered the problem. As I began removing decking boards, I paused to record the deterioration that caused the owner to contact me.

The old stain reminded me of weather worn whitewash on a New England coastal style house.

The pattern of boards was interesting but probably contributed to the deterioration and would certainly take more wood and more cost to replace.

Here was the real problem with the deck, a hidden hazard that I declared, “If you had had a party with 30 people on this deck, there may have been many of them in the hospital.” You see, the cracked 2 x 12 is bolted to the side of the post and expected to hold the weight of eight 2 x 8 joists. The 1/2 carriage bolts held, but the board did not. Notice the 2 x 8 at the right has dropped down with the settling 2 x 12. This is where the rise occurred on the decking boards, which must have been taking much of the weight as well.

The different perspective of the problem reveals more of the near failure of the joists.

I cleaned it all out except for the facing boards attached to the walls that had been under the overhangs with no deterioration.

The center post of the deck held a larger percentage of the total weight, so I increased the post from 4 x 4 to 6 x 6.

I did have to replace one facing board that was not holding well to the wall. I used numerous concrete screws and increased strength of the joist ends with joist hangers.

Take note that the joists now sit on top of the post, a much stronger configuration.

The part of the deck that you don’t normally see is the most important part that supports the weight, the part that takes the most energy to construct and get right, and the part many casually observers think shows little progress when being constructed.

In order to reduce leaf litter and deterioration, I caulked between brick and face plate.

And the decking begins!

The joints are not obvious and the area has a clean and spacious look.

The requested steps, near copies of the old ones were complex. I quit early this day for rain.

Getting standard stringers to fit the rise and run of available space is a significant challenge.

The lady of the house wanted the deck to have symmetry, so the landing and stairs running two ways.

Concrete for some reason that I don’t understand causes quicker deterioration of treated wood than straight clay. So I have taken to putting tar on posts to lengthen the their life.

Wow! It’s finished. All that I need to do is stain it. I finish it off with a belt sander on the railing especially and any other place that looks rough.

And there it is in its light gray stain, all matching the brick and trim and gray, wicker deck furniture and white, metal furniture that we moved onto the deck a few days later. Another good challenge for Decks and Such completed.